stator

Hi all! I just bought a 2000 fe600e and it runs great for about 20 minutes then backfires and flat out dies. I’ll let it sit a few minutes and it starts right back up and runs a couple minutes then dies again. Ive gone through the Dellorto carb fully. Checked float height. New spark plug...

Hey guys! My name is Alex, I'm 30 years old and living in Austria. Until now, I've joined the German forum from the moment I purchased my '04 FS 650. It's been nearly 5 years now and as time goes by, I've faced a few issues with the bike yet, but I could handle them myself with a little...

Hi folks, Upon gutting the aftermarket street wiring conversion on my 08' FE 450 in place of a purchased complete factory harness from an 06' SE 650, I found a Trail Tech rectifier that is almost twice the size of mine. So I got a bit excited & jumped into the tub I have the dropped valve 650...

Hey guys I have ST5500L stator on my bike from electrex and I think its dead, I wanted to go for a ride yesterday but I have no spark, I tested the 3 wires, black and red show 1 on multimeter, green and black show 0,shouldnt there be atleast some small resistance or is it completely dead, I...

Last week I bought an '08 FS650 with charging issues but with only 1500km and about 20 hours. According to the previous owner this was due to a faulty stator. Today I went through the electrics to ensure the stator is broken before I order a new one with the following results: - Pulse generator...

Hey y’all I have found out my stator is faulty, red to black checked out to 750ohms. I ordered a new replacement stator from RMstator and im having nothing but troubles. I’ve ordered a new electrex unit to replace it. Anyway I was wondering if my SEM stator would be rewindable? From the amount...

I had purchased these as backups but ended up making covers for my existing cases so no longer have use for them. The paint is worn but no deep gouges. $75 shipped for both if within the US.If you are international I would need to charge actual shipping. If my pricing is at all out of line...

Hello guys! I've recently bought a FE 600 2000 street legal supermoto. When i bought it started and ran great, but when i rode it a little a couple of days ago and stopped it did not start again. The spark plug gets wet so it gets gas, and when i pulled the spark plug out and tested it...

Been a while since ive been here. How is everyone? Trying to find a aftermarket stator with a higher output so my battery will atay charged while running a fan. Trail tech??? Thanks Bob

HI Battery wouldn't charge so I did preliminary tests with multi meter which indicated stator was grounding to earth. I removed stator and found small metal debris pieces which had caused damaged to stator and to wire insulation. (photos attached) (Not sure whether to post in Electrical or...

Hello, As part of the winter refurb, I'm wondering about how to freshen up the appearance of my two side covers. The stator's not bad, but the water pump and clutch covers are peeling the paint badly. What I'd really like is some form of reinforcement - for my DRZ and 690, Thumpertalk and...

Well guys, I THINK I finally have the ignition and wiring sorted and am about ready to get the old beast going. But... I need a throttle cable (or a set of them?). But, without ordering from GB, does anyone know where I can get one?. The only other remaining question I am battling with is...

I checked the stator on my 02 husaberg FE 501 and these were my results Red-black 3057 Green-black 176 Are these good numbers for this stator? I'm having trouble getting the bike to start. I checked and cleaned the carb, changed the fuel out replaced the spark plug, disconnected the E stop...

Hi bergsville, I'm on a bit of a mission to find out if the problem I experienced this weekend is a common fault or not. I had six different blokes in the forest telling me that my stator had packed up when my TX300 wouldn't start halfway through a trail ride event. Is this a common...

Hey i messed up wiring from my voltage regulators attatchment plug. so now i have 3 yellow wires missing their places. theres 2 yellow and 1 blue in that plug that comes from stator. (original sem) bike is fe 501 2000 Any help? pictures?

Hi all, My stator has failed, the red black circuit resistance value is way off and only giving me about 10-11 VAC under crank condition. It's Sunday here in Australia and I'm meant to be leaving for a three day rally this coming Friday. I don't think I have any chance of getting a...

Hello Husa Bergs. After a whole month of researching "normal" Husaberg problems, it looks like the stators burn out every so often. Back around 1980 Kawasaki went to huge lengths to lessen "flywheel" effect, to allow engines to rev up faster, and lower overall weight. My `81 KZ1000, with a few...

Hi! I noticed weak spark on my Berg and checked the stator. Between red and black i had 100kOhms, should be 3kOhms... So i wonder if I should buy a rewinded SEM stator or if i should go for the Elextrex stator? As i see it the elextrex have the advantage that you could get a 3 phase...

Ok 1997 HusaberG 400 So my bike was running great , then suddenly it just stopped, go it to run another 1/2 mile then died again I checked for spark and couldn't see any It was raining a lot !!! I phoned a friend to pick me up and got towed back home after waiting half a hour in the...

Hello, I have a Husaberg 600FE 1995 and Im pretty sure that my stator is busted( I havent mesured it yet) I have the SEM-system. Is it possible to buy this stator(not original but improved) without burning my cdi? http://dirtypart.com/laddaupp/filer/T%C3%A4nd%20delar%2032%20004.JPG I dont...