starter

Hi Everyone Is it possible to fit a later model starter ( 2008 ) into my 2001 fx 470e husaberg? Thank you in advance Ray

Afternoon chaps, After a winter lay up i'm just trying to sort the odds and ends on my '04 650 'berg. The first thing I need to sort is the starter just spinning when using the electric start. Is there a repair kit i can get? what do i need before i tear anything down? I'm just pulling...

Been having some issues on my FE570 09 lately. Symptoms being random slow turnover while actuating the start button, and last ride it cracked up intermittently while riding. Today I went down to the bike pushed the starter button with ecu detached and it was slow turning, grabbed the cable...

Good Day all, So over christmas i installed a new starter Motor, Bendix, transfer gear, starter relay and battery. Tried starting it cold engine turned over slowly but would not fire. Tried it when warm and the starter relay went and its never even started the bike! I have noticed 1 of the...

I have a 2007 550 and I had to replace the clutch cover gasket. After doing so my kick starter will no longer move. The bike will still start and run fine with the electric start but the kick starter will not move at all. Can anyone let me know what is going on here and how to fix this? Like i...

Hi all. So I've just put my FS550 back together after installing some Kibblewhite dual valve springs and my kick starter is stuck! I'm a bit baffled by this as I didn't touch it or remove the clutch. Had to remove the whole left side cover to fit my new cam chain but I didn't think this should...

Hello guys! Im new on the forum and its my first thread here I got a problem on my Husaberg when I just took the electric starter off the engine for checking the brushes and bearings, every looked fine so I took in place again and when I was trying to fire it up with the e-starter its just not...

hello folks,can someone please tell me the way the starter relay is hooked to battery? its a 2006 550 im unsure if the starter cable goes to top or bottom connector on the starter relay?? thanks in advance

Help!! :( I have a 650FS 2008. I have removed the gearbox cover on the left side of the engine to replace the sealing on the water pump. Then i hear a sound from the kick starter while removing the case.. Now that I'm going to reassemble, the kick start will not move. It is...

Hi, I rebuild an FE400E 2002, and I have a question about the value for tightening the nut and the smaller gear. I unmounted the clutch without TQ wrench, and before read somes post of this forum. :cry: Can you give me a approximative value, I will do somes adjustement to have the...

Fs650 starter repair using japan honda parts FS650 as many husabergs uses Mitsuba SM14 electric starter. KTM doesn't sell parts for this starter and you have to buy a new one at price between 150-350 euros. It is a very common electric starter,here are some models that use it with some...

I was riding and fell into a puddle and the handle bars fell in the water where the electric starter button was fully submerged. The button stopped clicking into place, so I pulled it apart and cleaned it all out and put it all back together and the switch isn't clicking into positions and...

if i'd like to start my Fe 450 2009 I can't, the starter makes an strange noise please help.. Thanks :(

Hi all, I'm trying to figure out a good battery solution. I'd like to try to understand the power spec and real-world power usage of the electric starter. It looks like the starter only pulls 50A max? I'm not sure though!: The 2012 570 manual specifices a "E-START. ENGINE CPL. 0,45KW...

I have a 2008 Fe 650 with 32 hrs that just started to have this problem. It cranks over for 2 seconds then starter gear must just pull in and spin. It kicks in on the initial button push but after a couple of cranks it pulls out and just whirls. I've searched some of the forums and see a mention...

Hi, half through a ride yesterday the bike wouldn't start. Tow started fine. The starter motor doesn't kick in. Just a whining sound. Battery fine, 20A fuses okay. Starter relay engaging. It's also intermittent. When it turns over starts immediately Any ideas?

hi, i have an 04 fe450 that slips on the starter when cold, it had a full rebuild 46 hours ago at taffys and had all the starter upgrades fitted, the garter spring on the sprague snapped so i put the original garter spring back on but still no joy, if i tap the start button it will grip and turn...

Hi all, I've been searching the forum a bit but I want a bit more clarity. As title says I have a 550FE 2005 which on last ride the starter just died. It semmed to be the battery at first because the starter kinda slowly died (getting weaker). So what I tried was following: - Charged battery -...

Hi all, Just acquired my first Berg. 2004 FE 550 Thought I should have at least one 4 stroke. After a 10 year hiatus from riding Id held onto just one bike. 1988 Husky-Cagiva WRK250. Resto is complete bar bolting it together Basically retired these days. Building a moto + Enduro X...

Hi, I intend to replace the clutch starter motor sprague spring, I have now removed the clutch plates but am stuck trying to remove the 27mm nut. I cannot get the locking tabs up, have tried a flat bladed screw driver and and pliers but don't have enough room, any ideas? Also, will the...