plug

Can anyone tell me what sump plug I can exchange for a 2004 fe450? The original ones seem to me quite scarce. Can I exchange with ktm or husqvarna? And what are the measurements? Mine is stripped and unrecognisable. Thanks Brenden

Hello, I cannot find exactly where the spark plug is though I have an idea that it might be the plug with the label "NGK" shoved into the engine. The problem is the manual is very barebones and does not explain how I can check for spark, though I am 100% I'm missing spark out of the 4...

Guy's, has anyone had there plug cap popping off while riding? Plug tight, new NGK cap with new rubber seals. Cap ratchets onto plug tight and pushes snug into head cavity but pops off. Stays on when rubber seal removed from bottom of cap! Doin my head in is it due to air expanding under cap...

I bought this bike for my wife 09 fe 450. While chasing an electrical problem with the headlight, (bad ballast) I noticed this component had a broken wire. I'm either skipping over it in the repair manual or its not there. Anyone know what this is?

Hello Huseberg forum. Having an issue with my oil drain plug. Threads got stripped, will have to repais using a time insert. How ever does any one know if it is possible to drain the oil via the oil screen plug? And just leave the oil plug resting still, dont wont to upset those fragile...

As our bikes age this seems to be a possible issue that causes a lot of tail chasing . It has multiple symptoms that could have you thinking fuel injector, fuel pump , fuel filters . The husaberg OEM can be replaced by NGK VBO5E NGK part number 8408 Symptoms: flame out as bike is...

Hello guys, so I bought my 06 Husa fs 650c about a Year ago, and ride it like 25h or something till now, I don't know the engine hours because it's the C model (came without Speedometer) the bike looks great and runs great whit no strange noises from the engine, and every time I change the oil...

2002 FE650 The wiring is a mess, and it is missing the starter relay. I have it starting 1-3 kicks with the kickstarter and want to remove all the electric start items. I bought the OEM aluminum plug from a FC470 to fill the hole, after the starter is removed. I expected a groove to be...

I just bought a 2004 fs450 a few weeks ago, has 130 hours on it, previous owner rebuilt it at 100 hours. I just did my first oil change since I bought it and there was a lot of fairly large metal chunks and shavings on the drain plug. Screen was clean, filter was clean as well. I’ve heard that...

As above The cap, I'm guessing has been changed at some point or even the coil all together Any ideas what k ohm plug cap I would need, the one on there is 5k ohm but I don't know if its right

2010 FE570 came with a number plate. Can someone tell me which plug is for the OEM headlights? And is there a high-low on the FE?

2011 570FE i just went to do an oil change and started talking the drain plug out...a minute later i realize i was still trying to remove the plug....stripped. Any advice on next steps? need to first figure out how to get the bolt out, then been reading about helicoils, etc. hoping i don't...

I pulled my spark plug today (first time since I bought the bike) to have a peek at its condition, and lo and behold the threads were coated in oil. That's not good. I also pulled my breather checkvalve and it had some pooled oil inside, so I'm hoping it's coming from there and not the rings...

Just put the first 1.5 hours and 100km on my rebuild. I rode around the block taking it easy after rebuild, dropped the oil, couple little bits of metal, some gasket material. Did about 100km yesterday, not beating on it too hard, kept the RPMs fairly low. Dropped the oil again, I have 1...

having just bought husaberg 650 supermoto i was doing oil change has anyone had difficulty removing oil screen plug im finding it near impossible to remove any ideas would be appreciated

I'm in the middle of re doing my wiring harness I have every thing done but one plug... I can't find it in any of the wiring diagrams or even where it goes on the bike... I know it's not the injector, map, tps, temp, stator pickup, roll or power relay....

Hi guys, Just trying to do an oil change on my Fs570 and the oil screen plug bolt is stuck..is this a reverse thread or something? it shouldnt be this hard to remove..ive been trying to turn it anti-clockwise to remove it. HELP PLZ!! :o

I've got an 09 FE450 that needs a new spark plug cap. The current cap shows infinite resistance. I was hoping to ride this weekend. So I go down to the local KTM/Husaberg dealer, Carter Powersports in Las Vegas. They do not have any caps. They do not stock the caps. There are no...

Please post your tips on getting this piece of **** out. Gone through 3 different 16mm sockets and I can't get either to grab. Deep sockets, thin sockets. Doesn't make a dime of sense.

70 degree here, I have this new coil. The coil came without the spark plug cap. If I pull the old cap off will it be ruined? Does it grab the wire such that it cannot be pulled off? TIA