issues

Finally! Valves at one sixth Carb tweeked Torque limiter shimmed Freewheel sprag renewed Shorai battery fitted R6 starer motor Heavy duty live and earth cables Boom! The only issues were that with the moto-x rotor the battery won't charge and the choke was impossible to reach with the tank on...

Have a problem with a Husaberg 650 2008 engine in my crosscart ! You can not shift from first to second gear . Without it lands on the neutral between ! All other gears are operating properly , and from neutral to second it is nothing strange . Anyone have tips on what can be wrong ?

I was thinking of going 16-48 for a long dual sport ride this summer (some highway, a lot of gravel roads, very little of any harder stuff). my local Mechanic is saying 16 will have clearance issues and even 15 might be too big. can anyone give some feedback? I see the parts manual listing...

Hello, I am new to this forum and pretty new to Dirt bikes in general but hoping this great community can help out. In short I bought a new battery for this bike because the old one appeared to be dead. After about 2 hours of riding and 5-10 starts my battery was dead. I trickle charged it...

I would like to introduce myself as a new member to the group coming from Australia. I have recently purchased off my brother in law a 2009 FE 570 and am looking for some help re some issues I bought it with.(Knowingly only paid $1200) The bike will start and idle no problems, once I get on...

Hey Guys, just bought my first Husaberg, 2010 FE450. Love the bike, but its too tall for me, 30" inseam. I have it at WER Enduro now in NJ to get the suspension worked. I need to lower the bike about 2 1/2" but I dont know if that is too much to lower it, will I be compromising anything? Also...

I have a 2010 FE390. I love the bike, but I'm having fueling issues. I replaced the spark plug, replaced the fuel injector, replaced the fuel pump filter (pump seems to work fine), replaced the inline filter on the fuel line, and just had the valves inspected (still in spec). I am still...

Hi, I am having fueling problems with my 2010 FE390. It was running fine, then I started to have fuel delivery issues and backfiring. I thought it was the fuel map, but all three of the ignition maps gave me the same result. I tested the fuel pump, and I could hear it prime when I tapped the...

Guys, please help me out here :) I changed fuel pump this summer, however I can not make the hose stay on the pump flange for any length of time :/ I used a submersible normal type of hose that I know is submersible along with a standard hose clamp, hose is definately submersible as I use the...

Hi Guys, I past my test last week :) so happy. Managed to get out on some green lanes near home and up to a old quarry thats been used for years by trialers and the like. Its the first time id got the bike up to any speed and i found that it wasn't running right. Ill try and describe it...

Hi All The berg has been grounded for months now, ive been so busy lately and it kills me to see it the way it is. Lucky for it though, very soon Ive got some time to put into it to (hopefully!) get it looking and running like new. Three months ago one of the exhaust conical springs broke...

hello all, I just bought a 1997 Husaberg fe400 and its a blast to ride. the bottom end has a ton but once I get half way through the RMPs it starts to bogged down really bad.... I am new to Husaberg so I don't know much about them mechanically. my guess would be these bikes are geared low for...

I just got a 99 fe 400 e. it runs really good. problem is it runs with choke open. close the choke and it dies. any idea what is going on? it does have a small split in the boot going from the airbox to the carb. would this effect the choke like that? Any help would be greatful!!

I'm going to check out a 2012 TE300. Has about 150hrs on it. Top end was done about 40hrs ago. New electric starter and battery. Anything specific too look for? Also, should I skip 2012 and look for a 2013 or 2014? Seems to me there was a redesign. I don't race, just trail ride for...

Hi Guys, Just got a *cheap* 09/1999 FE400 with an alleged ignition fault. Found a broken wire on the coil pack and voila good spark restored :) A 12mm plug has been bodged into the head, so a heli-coil back to 10mm needed. The real bad news is... still no starting or even a fire off ether...

Hey Guys, Guess this is my first post but loving my Berg!!! Riding in Colorado a few weeks ago and sounded like 1st gear was shearing. I immediately took it back to camp. I was having some clutch issues (not bled properly) and think that played a role. As clutch released and gear engaged...

hi my names luke. so ive got a 2001 400Fe with a 501 engine, (unsure of the year of engine) its not too bad to start on the kick start .. so my problem is with the E start, someone removed the manual decomp lever cable before i owned it) i have re fitted one and set it to what i think is ok, i...

Hey, i flipped my bike last ride, and now, my tail light isn,t working properly. The brake light is just stayin on. Input from either brake or headlight switch isn't making a difference. Any idea's?

Hi everybody ive recently bought a 2003 fe400 and im in a bit of a pickle, ive had to replace my ignition keyswitch as it was nackered. My question is, in my hurried attempt to fit i removed the old one and didnt mark up my wires so now im stuck with a bunch of ignition wires which I have no...

Hello all. I'm fairly new to Husabergs, and when I got the bike it had a seriously high idle it would start within two to three kicks. I had the valve cover off to tighten the timing chain tensioner that had come loose. I noticed that where the choke line fastened to the carb it had backed its...