hot

Hi guys, I have been having problems with my FE550 2004 for some time now so that the bike stops when hot or chokes if hot and using a lot of throttle in sand or uphill. So far I have changed the stator, pulser coil, ignition coil, spark plug connect and checked the fuel cap for venting...

I have a problem with my 501 when it's cold it runs just fine but as soon it get to working temp the problems start at first it won't idle later it just stops. Anyone that can help me?

Hello, first of all I'd like to say what a great resource this is, just bought 07 650 last week so I'm new to the forum and this is my first post. The bike starts easy on the button when cold but after a few mins begins to bog until the engine cuts out.I'm told by the previous owner that the...

I did some searching, but could not find any references to my problem. I've got an 09 FE450, fuel injection. It has recently decided it doesn't like starting when it's hot. Starts OK when cold. I pulled the choke ( idle speed adjusting screw) out and it starts right away. I just changed the...

The header pipes on my fc 470 are glowing red hot aft only a few mins of running. Coolant al seams to b ok and tick over is fine. I only noticed when i turned lights of in shed and could see they were bright red. This isnt mormal is it? Any advice is welcolm Thanks...... Andrew.

Hi i have a 95 husaberg fc 600 it starts up with choke from cold in about 3 kicks but when the bike is hot it can take upto 20 kicks to start it again. any ideas?

Hi guys Had my berg for a few months and always been spot on and first or second time starter. Took it out today and started first kick, but when it got warm it struggled to tick over and it wouldn't re start no matter how many times I kicked it over? It's always started great when hot...

Have a funny scenario happening lately, just rebuilt this old hotrod and installed a mikuni phm 40 pumper carb and a ton of other mods which could be throwing something off......spes exhaust, high comp piston, pod filter, taffy sledge, mototuneusa ported heads, '08' camshaft, Cant kick start...

Evening all, FE 4500 08 (old type) has been running grand but recently when trying to restart it, it has become addicted to the hot start. It's not needed from cold, couple of twists of the gas, choke on and away she goes (foot or electric). But.. when warm (running in temps from -5 deg C to...

FS570 Commuter I did the usual 1000km oil change on my fs570 the other day and followed that with a coolant drain and then refill. also did new chain and sprockets was 13/38 now 14/40 both renewed fluid levels are as they should be, but since the service i must say she is running very hot...

Hi there! My 550 has the following symptoms; runs very strong from closed throttle to WOT for +- the 1st 30min Thereafter, on pilot jet, it literally runs as if the choke is out; sputters, won't idle etc. Once it manages to get on the main jet, it pulls like before again. Other info: -It has...

Hi Everyone, I'm new to this forum so go easy on me please. I have an 09 FE570, owned since new. Recently, it has become very hard to start when hot. No problems when cold and it ran fine in all conditions. I also noticed if I left the ignition on, the fuel pump would cycle/prime every minute...

I'm seeking for a HOT camshaft for supermoto competition. What is the best camshaft around for medium-high rev power.

I brought this bike about a year ago not running,had been sitting for a year or so I believe,So I got a upgraded stator from Taffy and it changed my life,finally got to take the bike out for a few rides,what a beast,had many goodtimes so far,would love to post a couple of photos to show you...

I have a problem with my FE 400 2002. When really hot it will cut out but only on idle. It starts ok when warm and you can wring it`s neck all day long but when it comes to a stop and it builds up a bit of heat it cuts out. It idles fine when cold/warm and only does it when it`s hot. Is...

Hi All Ive been reading some posts and have some tests to do but help would be appreciated. My nephews FE501 10/02 models stator died on the first ride he went on a few weeks ago so I replaced it with an electrex one as thats all I can get here in OZ. It ran well for a couple of hours then...

I couldn't find a similar issues in the previous posts...so: Cold starting no problem, but after about 10 min of riding I have to put the bike in neutral and pull the hot start on the carb, crank it for 4 seconds and then give a blip on the throttle and it will start up. Would this be exhaust...

Yea so I was riding home from work and she just died! Almost restarted for a sec.. but NOTHING! I had to push the bike then I remembered that I had just installed a cv4 blanket and may have forgotten to plug in the low fuel indicator wire.. so I was 15 feet from a gas station when I stalled...

Well it happened again. I was out riding at a OHV park messing around and I accidentally stalled the bike. It would not restart and the FI light was not flashing. I tried several times every couple of minutes and it wouldn't start. Finally I waited 15 minutes for the bike to cool down and it...

For those who ride slow technical stuff of sometimes sit in traffic, I highly recomment wrapping your exhaust with a thermal insulating wrap. I wraped mine with a DEI 1" wide wrap and SS ties. Then painted with the silicone spray. The reason for this started when I shot the engine case and...