Husaberg
Go Back   Husaberg Forum > Husaberg Forum > Husaberg

Husaberg Husaberg Forum - Husaberg Motorcycle Forum


Thanks Tree2Thanks
  • 1 Post By Rainerio
  • 1 Post By berglsmerg
Reply
 
LinkBack Thread Tools Display Modes
August 6th, 2017, 10:28 PM   #1
Member
 
Joined: Jun 2012
From: Baulkham Hills NSW

Posts: 40
Thanks: 0

I Ride: 2011 Fe390 2010 Fe570 motard
No Spark No Fuel Pump noise.

Hi guys, was out riding over the weekend (about 80km) when I shut the berg down. It was off for less than a minute then tried to start and it would just crank, took the seat off and tried to start it to hear the fuel pump and nothing. I have checked all fuses in the fuse block plus the Yellow ones nothing seems damaged, even swapped them around, still nothing.
I got a multimeter onto the plug for the fuel pump, the one under the seat near the air box, no power to it.
I took the spark plug off and put a new plug in and tried to earth to the engine block but it has no spark as well.

Im guess its an electrical thing, maybe a loose wire, or coil? has anyone had a similar issue, maybe where I should start looking first?

I have a lithium batter in it and has very good crank
the bikes a 2011 FE390

Thanks guys.
B3RG is offline  
 
August 6th, 2017, 10:49 PM   #2
Senior Member
 
Rainerio's Avatar
 
Joined: Jun 2013
From: San Francisco CA. USA

Posts: 831
Thanks: 187

I Ride: 7 Husabergs two FE570S,FS570 FE390/450,07 FE650,05 FE550,2 Husqvarna's 86 WR400,87 510,09 Buell
If it turns over Look at Falcolion post try the fuel thing first just to see if can run. Then electrical.
Thanks from B3RG

Last edited by Rainerio; August 6th, 2017 at 11:18 PM.
Rainerio is offline  
August 6th, 2017, 10:59 PM   #3
Member
 
Joined: Jun 2012
From: Baulkham Hills NSW

Posts: 40
Thanks: 0

I Ride: 2011 Fe390 2010 Fe570 motard
Just had a read of that, but I'm not getting any power to the pump, I know what your saying but I dont think its a blocked filter. just no power to the pump to prime it.
B3RG is offline  
August 7th, 2017, 01:16 AM   #4
Senior Member
 
Joined: Nov 2011
From: Nordic countries

Posts: 955
Thanks: 405

I Ride: Two FE570 -12
Look at the fuses and possible fault codes.
jon andersson is offline  
August 7th, 2017, 02:42 AM   #5
Member
 
Joined: Jun 2012
From: Baulkham Hills NSW

Posts: 40
Thanks: 0

I Ride: 2011 Fe390 2010 Fe570 motard
yeah all fuses are good, cant see any fault codes displaying on the "Fi" lamp

Thinking its gotta be a wire somewhere or a faulty kill switch?
funny it was working until I turned it off, then wouldnt start after a couple of minutes ?
B3RG is offline  
August 7th, 2017, 03:18 AM   #6
Senior Member
 
berglsmerg's Avatar
 
Joined: Aug 2009
From: Charters Towers, Australia

Posts: 1,292
Thanks: 339

I Ride: FE 610 oh yea
Main relay under the head stock ? Don't have the wiring diagram in front of me but that supplies the ecu. Or try unplugging the ecu and reconnecting it.
berglsmerg is offline  
August 7th, 2017, 03:40 AM   #7
Senior Member
 
berglsmerg's Avatar
 
Joined: Aug 2009
From: Charters Towers, Australia

Posts: 1,292
Thanks: 339

I Ride: FE 610 oh yea
Fuses 1,3 and 4 are fed by the main relay, fuse 2 is a direct feed to the ecu from the battery ( not switched ) fuse 1 powers the ecu and sensors and is fed by the main power relay. The starter relay is independent. Check for voltage at fuse 1 while pressing the starter button. Also check the black and yellow wires behind the headlight for continuity to ground.
Thanks from B3RG
berglsmerg is offline  
Reply

  Husaberg Forum > Husaberg Forum > Husaberg

Tags
fuel, noise, pump, spark



Thread Tools
Display Modes


Similar Threads
Thread Thread Starter Forum Replies Last Post
Fuel pump again Rainerio Fuel 4 April 24th, 2016 11:26 PM
Need a fuel pump for 11 FS-570 floatn turd Fuel 3 May 21st, 2014 11:24 AM
fuel pump skred Husaberg 0 April 13th, 2014 12:04 PM
run out of fuel.. How to prime fuel pump? lyon90 Fuel 2 August 12th, 2011 11:21 AM
FE 570 Fuel Pump ?? FE570Ice Electrical 3 January 21st, 2010 11:47 PM


Facebook Twitter Google+ RSS Feed