Husaberg
Go Back   Husaberg Forum > Mechanical and Technical > Electrical

Electrical Electrical Forum - wiring and more


Reply
 
LinkBack Thread Tools Display Modes
September 3rd, 2019, 01:41 AM   #1
Junior Member
 
Joined: May 2019
From: Belgium, limburg

Posts: 5
Thanks: 0

I Ride:
Husaberg FS 650 (e) 2005 starting issue

Hi Guys,

One year ago i swapped my honda cbr for a husaberg fs 650.
Untill 2 months iíve never had any problems with it.
Now the problem is as follows:
In the last two months, it has happened several times that i go out for a ride (mostly 30-60min), i shut off the bike at a friends place or somewhere else. When i would like to take off again (after 30min), i canít start the bike anymore, looks like the spark is gone that moment. Normally iíve allways been able to start the bike with one kick. And when riding i feel no problems, bike rides like a train.

First time it happend i noticed that one of the yellow wires was damaged by rubbing the chassis, i fixed it but the problem didnít go away. Second time i noticed the cable to the spark plug was a bit loose, fixed it again but the problem still occurs. Third time i changed the spark plug but it still occurs.

Later, i noticed that the ground cable from battery to chassis shows a bit burned, like there was a spark in the cable, i donít know if it was allready there but that was the first time i noticed (probably from the first time when the yellow wire rubbed the chassis).

Now is the question, where can i look to solve the problem?
Had anyone else had this problem before?

Thanks a lot allready guys
IVCM is offline  
 
September 3rd, 2019, 01:49 AM   #2
Senior Member
 
Joined: Nov 2001
From: Ely, England

Posts: 15,785
Thanks: 463

I Ride: Husaberg FE501e 2003
so does the engine spin over?

taffy
Taffy is offline  
September 3rd, 2019, 07:35 AM   #3
Moderator
 
ned37's Avatar
 
Joined: Dec 2004
From: back in cottonwood, az

Posts: 2,360
Thanks: 206

I Ride: '08 HUSKY te610
too rich on pilot?
ned37 is offline  
September 3rd, 2019, 10:11 PM   #4
Junior Member
 
Joined: May 2019
From: Belgium, limburg

Posts: 5
Thanks: 0

I Ride:
Originally Posted by Taffy View Post
so does the engine spin over?

taffy
Engine spins like normal. It just seems to mis a spark at that moment to get it running. Next day it will usually start again though by doing actually nothing..
IVCM is offline  
September 3rd, 2019, 10:14 PM   #5
Junior Member
 
Joined: May 2019
From: Belgium, limburg

Posts: 5
Thanks: 0

I Ride:
Originally Posted by ned37 View Post
too rich on pilot?
I donít know the jetting by head but the problem occured only 3 months ago, never happened before
IVCM is offline  
September 4th, 2019, 03:52 AM   #6
Senior Member
 
Joined: Nov 2001
From: Ely, England

Posts: 15,785
Thanks: 463

I Ride: Husaberg FE501e 2003
year?

taffy
Taffy is offline  
September 4th, 2019, 03:55 AM   #7
Senior Member
 
Rainerio's Avatar
 
Joined: Jun 2013
From: San Francisco CA. USA

Posts: 991
Thanks: 243

I Ride: 8 Berg’s 2005-2011 2 Husky’s 1986&7 2009 Buell & 2006 Ducati
Not going to be the problem but go through the carb. Clean replace anything that might be a problem later. Can't hurt. If you the time look at and clean wire connections , switches grounds/earth would be were I'd start.
Rainerio is offline  
September 4th, 2019, 07:32 AM   #8
Moderator
 
ned37's Avatar
 
Joined: Dec 2004
From: back in cottonwood, az

Posts: 2,360
Thanks: 206

I Ride: '08 HUSKY te610
just for fun, turn in the pilot fuel screw under the front of the float bowl a half turn and see if that helps.
ned37 is offline  
September 4th, 2019, 11:04 AM   #9
Junior Member
 
Joined: May 2019
From: Belgium, limburg

Posts: 5
Thanks: 0

I Ride:
Originally Posted by Taffy View Post
year?

taffy
2005 model

Another thing that might help to find the problem: Approximately 5 months ago, I installed 4 LED turning lights, in order to make them work and flash correctly, I also installed another relay. Could this give an error or something like that?

Driving season is about over so now i’ll have time to clean the carb and check all wiring!

Last edited by IVCM; September 4th, 2019 at 11:17 AM.
IVCM is offline  
September 4th, 2019, 02:42 PM   #10
Junior Member
 
Joined: Aug 2019
From: Weeki Wachee, Fl.

Posts: 2
Thanks: 0

I Ride: Husaberg FE400E Praga ED610 KTM 400 SC And many others
Stator and or coil. They fail when hot.
Danner is offline  
Reply

  Husaberg Forum > Mechanical and Technical > Electrical

Tags
2005, 650, husaberg, issue, starting



Thread Tools
Display Modes


Similar Threads
Thread Thread Starter Forum Replies Last Post
FE450 2010 starting issue Frenchy Electrical 15 July 4th, 2016 07:05 AM
Starting issue allkidd Mechanical 5 March 22nd, 2014 01:31 PM
2005 FE550 Signal Light Issue robp Electrical 5 April 11th, 2011 04:05 PM
FE 570 starting issue oneal Electrical 15 April 30th, 2009 02:49 PM
Starting Issue DOLLARS Electrical 7 May 16th, 2006 01:33 PM


Facebook Twitter Google+ RSS Feed