Husaberg
Go Back   Husaberg Forum > Mechanical and Technical > Electrical

Electrical Electrical Forum - wiring and more


Reply
 
LinkBack Thread Tools Display Modes
July 17th, 2015, 11:11 AM   #1
Junior Member
 
Joined: Jul 2015
From: UK

Posts: 4
Thanks: 0

I Ride: Husaberg 450 2005, Yamaha WR125
Husaberg 450 2005 starts when battery is connected

having an issue with my 2005 450,

Whenever i touch the positive to the battery to connect it up, it starts sparking and trying to tick over, it was in gear at the time and even started spinning the chain, what's most likely to be the issue?

Thanks in advance!
Harry450 is offline  
 
July 17th, 2015, 11:42 AM   #2
Senior Member
 
Rainerio's Avatar
 
Joined: Jun 2013
From: San Francisco CA. USA

Posts: 901
Thanks: 211

I Ride: 7 Husabergs two FE570S,FS570 FE390/450,07 FE650,05 FE550,2 Husqvarna's 86 WR400,87 510,09 Buell
First thing disconnect your starter switch. Then try it. Not knowing this bike I I'd start there.
Rainerio is offline  
July 17th, 2015, 01:48 PM   #3
Senior Member
 
tourist's Avatar
 
Joined: Nov 2012
From: Iceland

Posts: 2,276
Thanks: 721

I Ride: 1 Berg, 1 Zook
ayup, +1 on rainierio

do you have a multimeter? ohm-test or beep-test the switch (can be done on the plug or if probably if you screw the switch apart (watch for small flying bits?)

that said, my 570's starter lurched the bike when I somehow prodded/pushed what I believe is the starter relay in the fuse/electronics compartment, I assume the relaay can close if it's squeezed somehow
tourist is offline  
July 18th, 2015, 12:09 AM   #4
Senior Member
 
Joined: Nov 2001
From: Ely, England

Posts: 15,409
Thanks: 397

I Ride: Husaberg FE501e 2003
it suggests that the starter solenoid is 'open' and that the four wires into here are wrong.

I don't have a complete bike here at present but I'M SURE SOMEONE HERE CAN TELL YOU THE ORDER OF THE 4 WIRES INTO IT CAN'T YOU LADS...................

there is also an M and B on the solenoid. check that the battery wire goes to the B and the other post has the wire to the starter motor.

regards

Taffy
Taffy is offline  
July 18th, 2015, 12:46 PM   #5
Junior Member
 
Joined: Jul 2015
From: UK

Posts: 4
Thanks: 0

I Ride: Husaberg 450 2005, Yamaha WR125
thanks for the advice guys!
going to give it a go tomorrow
yes I've got a multimeter, will check that as well!
Harry450 is offline  
Reply

  Husaberg Forum > Mechanical and Technical > Electrical

Tags
2005, 450, battery, connected, husaberg, starts



Thread Tools
Display Modes


Similar Threads
Thread Thread Starter Forum Replies Last Post
Battery Husaberg FE 650? Finnar Electrical 8 March 18th, 2014 02:04 PM
2005 Husaberg FE 550 HusabergFE550 Husaberg 8 April 16th, 2007 10:24 PM
My Husaberg is too fast, too light, and starts too easily. doctorcorey Husaberg 15 March 6th, 2006 09:18 AM
fe 450 e mod 2005 only starts with kick berg-mex Mechanical 1 January 23rd, 2006 09:59 PM
My 01 E-Starts cold but battery does not charge up LeFrog Electrical 10 July 1st, 2005 05:55 AM


Facebook Twitter Google+ RSS Feed